FREE SHIPPING & HANDLING!*                           Order by 11 PM EST for Same Day Shipping!

JEGS Performance Products 40041 - JEGS DISG Complete Ignition System by ICE Ignition

JEGS Performance Products 40041 - JEGS DISG Complete Ignition System by ICE Ignition

JEGS Performance Products#555-40041

DISG Ignition System
  • Big Block Chevy (except tall deck)
  • Digital Ignition Box
  • Built-In Rev Limiter & 2-Step
  • (80) Pre-programmed Ignition Curves
  • Hall Effect Trigger
  • 9mm Spark Plug Wires (35 ohms/ft.)

    JEGS Performance Products 40041 - JEGS DISG Complete Ignition System by ICE Ignition Details

    JEGS Digital inductive spark generation (DISG) ignition systems are very different from to the commonly used CDI units available in the marketplace.

    CDI systems rely on multiple sparks which diminishes ignition power rapidly above 3000 rpm as there is insufficient time to generate multiple sparks in the ignition cycle. The JEGS Digital Ignition system generates much greater spark duration and total energy than CDI ignition through the entire RPM range.

    JEGS DISG Ignition uses much higher amperage to saturate the coil and deliver a more powerful spark to the plug. High speed microprocessors control the coil saturation precisely to allow maximum spark duration for longer fuel burn between 1000 and 10,000 rpm as shown in the graph. A more intense and longer spark delivers greater power potential particularly when using slow burning fuels like Methanol and Propane Gas.

    The JEGS DISG system uses digital spark management to provide easier starting and more precise and consistent spark delivery and system reliability. The JEGS digital system design is simpler, lighter and more resistant to vibration which is a common cause of ignition box failure especially in circle track applications.

    Every JEGS system is supplied with a severe duty race distributor with reliable hall effect electronic triggering, CNC machined billet body and roller bearing precision ground shaft for smooth operation. JEGS Ignition Kits are supplied with the most powerful ignition coil available and low resistance fully fitted 9mm JEGS Race wires.

    Includes:
      7amp Digital Ignition Box:
    • Switchable dual table crank trigger and distributor spark programs
    • Push button two stage rev limiter
    • 80 pre loaded push button ignition curves
    • Dedicated tach output
      Billet Distributor:
    • Chromemoly shaft
    • No advance weights or springs to wear out or fail
    • Maintenance free hall effect sensor provides provides unmatched trigger stability throughout entire rpm range
    • Brass (for use with solid roller cams) and Tufftrided Cast Iron (for use with hydraulic roller or flat tappet cams) Drive Gears
      9mm Spark Plug Wires:
    • Silicone-RFR Inner Insulation that is protected and reinforced by fiberglass braiding and then coated with an "Ultra Temp" Silicone Jacket
    • Low resistance (35 ohms/ft.)
      High Output Ignition Coil:
    • Ultimate combination of spark intensity and duration
      Wiring Harness and Installation Hardware

    Click here to learn about the differences between DISG & CDI Ignition Systems

    JEGS Performance Products 40041 - JEGS DISG Complete Ignition System by ICE Ignition

    To state it simply, this ignition system will give your engine more power throughout the entire RPM range! However, the technology that goes into building this ignition system is superior to anything else available.

    Unlike most high performance ignition systems which use capacitive discharge circuitry (CDI - Capacitive Discharge Ignition) JEGS DISG Ignition System uses Digital Inductive Spark Generation. The JEGS DISG ignition system generates maximum spark duration and intensity through the entire RPM range and the digital spark management provides more precise and consistent spark delivery and system reliability. The simple yet effective design makes it more resistant to damage from vibration. 7 amp digital ignition box features a built in 2 stage rev limiter and 80 preprogrammed ignition curves.

      Features:
    • Unlike other ignition systems that require separate controls for a 2-step or rev limiter the JEGS DISG Ignition System has them built right into the box.
    • Many ignition systems use a mechanical or vacuum advance. The JEGS DISG Ignition System has 80 preprogrammed ignition curves that are adjusted at the push of a button.
    • All of these features combine to give you the most complete and powerful ignition system available.

    JEGS Performance Products 40620 - JEGS Billet Distributor Hold-Down Clamps
    Only $24.99

    JEGS Performance Products 40680 - JEGS Electronics Mounting Plate
    Only $54.99

    JEGS Performance Products 28020 - JEGS Dielectric Grease
    Only $7.99

    JEGS Performance Products 81660 - JEGS Spark Plug Indexing Kit
    Only $54.99


    See All Items You Need